FIA asks teams to review braking systems after Mortara crash

The FIA has asked all Formula E teams to review the causes and effects of possible failures to their braking system following the Diriyah E-Prix crash that hospitalised Edoardo Mortara.

FIA asks teams to review braking systems after Mortara crash

Venturi Racing driver Mortara was taken for precautionary checks after a brake-by-wire (BBW) system fault caused him to crash heavily following a practice start in Saudi Arabia.

As a result, both Mercedes and the cars of customer team Venturi Racing were not allowed to compete in qualifying but were later cleared to start the Sunday night race.

Read Also:

Ahead of the Rome E-Prix double-header, the FIA has asked all teams to check the failure mode and effects analysis (FMEA) of their braking system. Manufacturers must submit a list that considers all scenarios relating to an issue in order to homologate their car.

A bulletin from technical delegate Laurent Arnaud read: “Especially if the driver loses the front brake for any reason (leakage, calliper issue), the system must be able to detect that and activate the rear braking (regen or BBW actuation).”

In Mortara’s crash, the brake pedal was fully depressed, but the front brakes were recorded at zero pressure which was likely the result of a possible leak.

The statement continued: “In the chassis supplier common package, [teams] have the displacement travel sensor from the tandem brake master cylinder. Those sensors must be used to detect any leakage on the brake system.”

Marshals remove the car of Edoardo Mortara, Venturi Racing, Silver Arrow 02, from a barrier after his crash

Marshals remove the car of Edoardo Mortara, Venturi Racing, Silver Arrow 02, from a barrier after his crash

Photo by: Andrew Ferraro / Motorsport Images

The FIA clarified that the root cause of the Mortara shunt had not yet been fully identified but “for the time being there is no concern on the chassis common parts”.

This suggests Mortara's crash was an isolated incident, despite Mercedes works driver Nyck de Vries appearing to suffer a similar issue that caused him to retire from the Mexico City race last season. 

That followed a BBW failure for Daniel Abt during practice at the Autodromo Hermanos Rodriguez last year, which led to a crash that required the former Audi driver to be taken to hospital via helicopter. 

The FIA has also suggested teams run with a paddle that drivers can activate to slow the car in the event of a brake pedal issue. Most teams run with such a set-up already.

DS Performance director Thomas Chevaucher, who replaces FIA-bound incumbent Xavier Mastelan-Pinon, told Motorsport.com: “In addition to that failure mode analysis (FMEA), the FIA recommend going in a mode so that the drivers can slow down the car using a paddle.

“In the case of a very severe multi failure on the braking system, the driver has an opportunity to slow down the car using the regen paddle. This, I would say, is an extra safety compared to a normal [internal combustion engine] car.

“We have the motor that can slow down the car if the brakes cannot for some reason.”

Porsche driver Andre Lotterer stopped on track in Rome with a minute of shakedown remaining due to a brake-by-wire issue.

shares
comments

Related video

New Dragon FE car now expected to debut in Monaco

Previous article

New Dragon FE car now expected to debut in Monaco

Next article

Rome E-Prix: Di Grassi fastest as FP1 ends with major crash

Rome E-Prix: Di Grassi fastest as FP1 ends with major crash
Load comments

About this article

Series Formula E
Event Rome E-Prix I
Author Matt Kew
Why Formula E's Valencia fiasco undermines engineering talent Prime

Why Formula E's Valencia fiasco undermines engineering talent

FIA president Jean Todt wanted more Formula E coverage in the media, and got his wish when the opening Valencia E-Prix proved farcical. Despite attempts to spin the race as teams failing to get their sums right, Formula E and its governing body cannot escape blame - especially when trying to get teams to commit long-term.

Formula E
Apr 27, 2021
How Valencia E-Prix farce gave Formula E an image problem Prime

How Valencia E-Prix farce gave Formula E an image problem

Formula E was under the microscope at Valencia, on its first visit to a permanent circuit. But after a mere nine drivers were left classified following Saturday's Valencia E-Prix, the electric championship once more faced criticism after rising energy deductions and miscalculations produced a farcical affair.

Formula E
Apr 25, 2021
How Vergne and Vandoorne found redemption in Rome Prime

How Vergne and Vandoorne found redemption in Rome

Another Formula E double-header, another double dose of frantic action. While the form guide remains unpredictable following fightback wins for Jean-Eric Vergne and Stoffel Vandoorne in Rome, the speed and consistency of Mercedes – both on and off the track – could have its rivals worried for what is to follow

Formula E
Apr 12, 2021
What Nissan's commitment to Gen3 reveals about Formula E's future Prime

What Nissan's commitment to Gen3 reveals about Formula E's future

Formula E's Gen3 era grid continues to take shape, after Nissan opted to commit to the series for another four years. Nissan's global chief operating officer explains why it has thrown its lot in with FE while other high-profile marques have decided to call it quits.

Formula E
Mar 24, 2021
Why the new Formula E season got off to such a controversial start Prime

Why the new Formula E season got off to such a controversial start

With the new Formula E season belatedly getting underway in Saudi Arabia, the championship appeared to try to make up for lost time with an overspill of action and controversy on and off the track. While some talking points could have serious repercussions, it was an explosive opener for many reasons.

Formula E
Mar 1, 2021
The eight major plotlines to watch in Formula E 2021 Prime

The eight major plotlines to watch in Formula E 2021

The delayed 2020-21 Formula E season gets underway this week with a double-header in Saudi Arabia. The testing times were too close to call a favourite, but that's not the only area of interest to follow as the championship enters a crucial year

Formula E
Feb 25, 2021
Why Formula E's 2021 season will be a crucial litmus test Prime

Why Formula E's 2021 season will be a crucial litmus test

As off-track politics threatens to overshadow events on it, the upcoming Formula E season is perhaps its most important since the championship's inception. And that's a shame, given that the focus should be on what promises to be its closest title fight yet.

Formula E
Feb 24, 2021
How Mercedes and Porsche can avoid a difficult second FE album Prime

How Mercedes and Porsche can avoid a difficult second FE album

Mercedes and Porsche compete to win and have done so across the board: in Formula 1, sportscars, the Dakar Rally and endurance road races - even working together to break land speed records. Next in the crosshairs is the Formula E teams' championship crown.

Formula E
Feb 17, 2021