Why Santiago will be toughest test for Gen2 cars

The second ABB FIA Formula E event in Santiago is likely to feature the championship’s hottest-ever race, which will test the technology on the Gen2 car like never before.

Why Santiago will be toughest test for Gen2 cars

With air temperatures predicted to reach as high as 37-38 degrees in the Chilean capital between 4-5pm – the hour of the race – there is a high chance the championship’s record race temperature (35 degrees set in Putrajaya in the 2015/16 season) will be surpassed. Such temperatures are in the region of Santiago’s own record.

This is set to test the batteries and tyres – both new on the Gen2 car for the 2018/19 season – in a way that is unlikely to be repeated, although of course not impossible, for the rest of the campaign. 

Ahead of season five, the general understanding was that battery temperatures would no longer be a problem with the Gen2 car. The batteries are produced by McLaren Applied Technologies and supplied to the FIA, which hands them to the teams. In the old Gen1 machine, once battery temperatures reached 55 degrees, the regen system would drop linearly until it reached 60C, at which point energy harvesting would drop from 100% to zero over the course of three-four laps.

This meant the drivers had to change their brake balance regularly to avoid front locking, all while managing total battery energy levels. Thermal degradation is understood to massively improved with the new battery, and tolerances are much greater, despite one battery now having to last an entire race.

The ‘magic’ (critical) level is now 72 degrees. The immense, dry heat in Santiago means there is a possibility for all teams that this level could be reached in the race on Saturday. 

If that happens, Motorsport.com understands that the cars will lose power in a significant way. It is possible to drop 10-20-seconds in laptime, although this will happen “progressively”, over the course of a few laps according to Audi’s Lucas di Grassi.

Lucas di Grassi, Audi Sport ABT Schaeffler, Audi e-tron FE05 follows Felipe Massa, Venturi Formula E, Venturi VFE05

Lucas di Grassi, Audi Sport ABT Schaeffler, Audi e-tron FE05 follows Felipe Massa, Venturi Formula E, Venturi VFE05

Photo by: Sam Bloxham / LAT Images

Temperatures will be critical from the start of the race. Two factors cause the battery to heat up most – using power and putting energy back in via the regen. Bodywork cooling is restricted by FE’s rules (although the teams are already allowed to move the bodywork to a certain extent), but air cooling and lifting and coasting will be critical to temperature control. 

The ‘damage’ in terms of rising temperatures is understood to occur on an exponential curve – gradually rising before getting dramatically worse as the heat level climbs. This ‘damage’ cannot be undone. 

FE observers reckon if the 72-degree threshold is reached and battery power shutdown occurs, this will happen in the final laps of the race. The 45-minutes plus one lap format could therefore become critical.

“You could see people leading the whole race and then, if the race is fully green, having problems with the temperature at the end,” says di Grassi.

This is a concern up and down the grid – as the battery is a common part, the temperature concerns will impact on all the teams. But each will have simulated this scenario ahead of the race.

“We’ve done our homework,” says Virgin Racing’s Sam Bird. “We’ve got things in place to combat that if it comes our way. For the first time we’ll see this new battery put under quite a lot of strain. Will people reach the magic number where people start to slow down? I don’t know, but it could be close.”

FE and the FIA are confident the temperatures will remain within the battery’s tolerance during the race – with no extra advice given to the teams on the subject.

The other factor that could be impacted by the intense heat is tyre wear. The lighter Michelin rubber used on the Gen2 machine was predicted to be a factor in the races ahead of the campaign, although it was not much of a talking point in Riyadh or Marrakech. 

Andre Lotterer, DS TECHEETAH, DS E-Tense FE19

Andre Lotterer, DS TECHEETAH, DS E-Tense FE19

Photo by: Molly Darlington / LAT Images

“The tyre factor will be the most unknown one,” says DS Techeetah driver Andre Lotterer.

This is because in Santiago, the new track in Park O’Higgins is a mixed surface – around 70% new asphalt from the opening fast right-handers at Turns 1-2 all the way to the 90-degree left at Turn 12. From there, the drivers complete the lap via the two hairpins and the main straight, which are on concrete. 

The anti-clockwise nature of the track and especially the long curve – punctuated by an extremely tight chicane at Turns 8/9/10 – will strain the rubber on the right-hand wheels. Cars are expected to slide, impacting on the tyre life and driver performance significantly. Keeping the best balance will be crucial and all of this impacts on energy saving at the same time.

As a result of these factors, two race scenarios are thought to be likely. With temperature and energy control crucial throughout the grid, a processional race plays out as the drivers battle the factors impacted most by the temperature. Or, as is more likely in FE, some drivers opt to use their energy and attack hard early on, gambling on a late-race safety car negating the battery temperature curve and the effect of the attack mode.

The effect of critical battery temperatures has been seen before.

During pre-season testing at Valencia, a mock race took place to test the attack mode race format system. The cars went out in single file from the pits, but had to return after just two laps due to cars stopping on-track. Even in the October sunshine – air temperatures reached just 23.4 degrees – the cars that remained in the pitlane during the 45-minute red flag stoppage gradually heated up. 

When the ‘racing’ did get underway – Alexander Sims, di Grassi, Lotterer and his teammate Jean Eric Vergne headed the pack. On the final lap, Sims led di Grassi, but found himself battling battery temperatures. 

On the run to the line the BMW slowed and the Audi driver won by a front wing.  

Lucas Di Grassi, Audi Sport ABT Schaeffler, Audi e-tron FE05

Lucas Di Grassi, Audi Sport ABT Schaeffler, Audi e-tron FE05

Photo by: Alastair Staley / LAT Images

shares
comments
Santiago E-Prix: Lopez tops practice for Dragon

Previous article

Santiago E-Prix: Lopez tops practice for Dragon

Next article

Santiago E-Prix: Di Grassi on pole but under investigation

Santiago E-Prix: Di Grassi on pole but under investigation
Load comments
Why electric racing cars should be four-wheel drive Prime

Why electric racing cars should be four-wheel drive

OPINION: Circuit racing has traditionally favoured front- or rear-wheel-drive setups, eschewing the equal distribution of power. But for Formula E and other electric-powered series, our columnist believes it’s a perfect fit.

Formula E
Oct 13, 2021
How motorsport's most prominent power couple found joint success Prime

How motorsport's most prominent power couple found joint success

The Wolffs have carved their own paths in motorsport, leading their respective teams to success in Formula 1 and Formula E. But the two came together last month as their drivers finished first and second in the FE drivers' championship - a feat they are hugely proud of. In a rare joint interview, they reflect on a remarkable season

Formula E
Sep 21, 2021
The top 10 Formula E drivers of 2020-21 Prime

The top 10 Formula E drivers of 2020-21

OPINION: The 2021 Formula E campaign was one without a narrative for much of the season, with no single car or driver able to break away from the pack. That makes choosing a top 10 especially difficult, particularly as the qualifying format meant some worthy performers were unable to enjoy their day in the sun.

Formula E
Sep 19, 2021
How Mercedes and de Vries achieved Formula E glory the hard way Prime

How Mercedes and de Vries achieved Formula E glory the hard way

When Nyck de Vries dominated the first race of what would be the most controversial and unpredictable Formula E season to date, it looked as though Mercedes was in for a cakewalk. But as the campaign wore on, the path to a title double became increasingly rocky. Neither driver or team would be assured of the crown until the closing stages of the very final race on a weekend of struggle in Berlin.

Formula E
Sep 17, 2021
The Formula E 'loan' deal that will keep di Grassi winning Prime

The Formula E 'loan' deal that will keep di Grassi winning

OPINION: The departure of Audi from Formula E meant its long-time driver Lucas di Grassi would need to find a new berth to stay on the grid. His deal at Venturi Racing will ensure the championship's first-ever race winner will remain competitive into the final year of the current Gen2 ruleset - although it may not be a long-term fit

Formula E
Sep 15, 2021
The problems laid bare by Mercedes' impending Formula E departure Prime

The problems laid bare by Mercedes' impending Formula E departure

Mercedes' planned withdrawal from Formula E at the end of the 2022 season will contribute to the big hole left by fellow automotive manufacturers Audi and BMW on their departures. Although the team may stick around under a different guise, the exit of the now-reigning teams' champion underlines FE's current issues...

Formula E
Aug 18, 2021
The F1 dilemma facing Mercedes' new world champion Prime

The F1 dilemma facing Mercedes' new world champion

After clinching the Formula E title at the Berlin finale, Nyck de Vries is a driver in demand. Although Mercedes would love to keep a reigning champion at the team, the allure of a Williams F1 drive may be too much for de Vries to ignore should a potential deal come to pass

Formula E
Aug 17, 2021
How de Vries claimed Formula E title glory as Mercedes exit bombshell looms Prime

How de Vries claimed Formula E title glory as Mercedes exit bombshell looms

As Formula E lined up to complete its seventh season at Berlin's Tempelhof Airport, all eyes were on who would be its first official FIA world champion. Despite Nyck de Vries' title lead heading into the weekend looking all but secure, the Dutchman held on - and enjoyed a good dollop of fortune - to secure a championship double for Mercedes

Formula E
Aug 16, 2021