Toyota reveals both cars suffered electrical glitch at Spa
Toyota has revealed that both TS050 Hybrids suffered the electronic problem that cost the second-placed #8 car more than half a minute in last weekend's Spa FIA World Endurance Championship round.
Pascal Vasselon, technical director of the Toyota Gazoo Racing Europe team, explained that the issue that temporarily put the TS050 engine into a protection mode hit the the winning #7 car driven by Mike Conway, Kamui Kobayashi and Jose Maria Lopez on one occasion compared with twice for the sister car.
The time loss for Kobayashi when the #7 Toyota encountered the problem at the end of the third hour was minimal because, said Vasselon, he was "faster to react".
Kobayashi and Brendon Hartley, who shared the #8 TS050 with Sebastien Buemi and Kazuki Nakajima, exited the pits together after a safety car just before the three-hour mark.
Both cars struggled to get up to speed, before Kobayashi raced away from his teammate after going through a series of reset procedures.
Hartley was unable to get up to full speed until he was halfway along the Kemmel Straight after Eau Rouge and finished his out lap 40s down on his teammate.
Buemi had run into the same problem in the initial stages of the race, losing approximately five seconds while leading in the wet conditions after the safety car start.
Vasselon said that Toyota had identified the problem resulting in "a lack of engine torque when accelerating from very low speed", but did not understand why it had occurred.
"We know what the problem is, but we don't know all the details," he said. "It is an engine protection mode that was triggered in some cases.
"It was present on both cars, maybe a bit more severe on #8, but it was in the background on both cars."
#7 Toyota Gazoo Racing Toyota TS050: Mike Conway, Kamui Kobayashi, Jose Maria Lopez
Photo by: JEP / Motorsport Images
Vasselon explained that there is "a procedure to go through to get away from it, a matter to go through".
Toyota had never experienced the problem with the TS050's twin-turbo V6 before last weekend's Spa 6 Hours, but it did happen to #8 on one occasion during practice for the event. It suggested that the issue was related to "circuit-specific settings".
The #7 Toyota ended up winning by 34s after Buemi had to make a late splash-and-dash fuel stop two laps before the chequered flag, although the positions of the two Toyotas had been frozen at the previous round of pitstops with 40 minutes left on the clock.
Nakajima had been just over a second behind Lopez at this stage after the fourth and final safety car of the race closed up the two Toyotas again.
The turning point of the race in the favour of #7 came in the opening hour when Conway was given slick tyres on a drying track, while Buemi was left on the wet-weather Michelins he had started the race and had to make an extra pitstop.
This allowed Conway to build a lead over the sister car of 50s, which stood at well over a minute in Kobayashi's favour when the safety car was deployed the end of third hour.
ByKolles hails "best ever performance" in LMP1 at Spa
Ferrari "still open" to building Le Mans Hypercar