Toyota admits to reliability concerns ahead of Le Mans

Toyota has admitted to concerns over the reliability of its new FIA World Endurance Championship contender ahead of next month's Le Mans 24 Hours.

The admission follows its pair of GR010 Hybrid Le Mans Hypercars suffering delays in last Sunday's Monza WEC round. 

The race-winning #7 entry shared by Kamui Kobayashi, Mike Conway and Jose Maria Lopez lost a minute with an electronic problem that required Kobayashi to bring the car to a complete halt on track to undertake a full reboot of its systems. 

Read Also:

The #8 GR010 of Sebastien Buemi, Kazuki Nakajima and Brendon Hartley lost nearly an hour with a fuel-system issue and also required a new front corner on the way to last place, 43 laps behind the sister car. 

Toyota Gazoo Racing Europe technical director Pascal Vasselon conceded that the team knows it "has some work to do" prior to the official Le Mans test day the week ahead of the double-points WEC round on August 21/22.

"Yes we are worried, but somehow it is business as usual for a racing team," he said. "We have to get to the bottom of the two issues."

Vasselon explained that Toyota's focus will be on rig testing between now and Le Mans, ruling out scheduling additional track testing.

The only run planned for the GR010s between now and Le Mans is Toyota's traditional pre-race shakedown at Spa, which will take place in early August.

"We need really to understand what has happened, then generate the conditions that are suspected to be the critical ones on the rig," he said.

"We have done 30,000km with the car; you cannot say you will organise a test and it [the problem] will happen."

 

Vasselon described the issue on #7 as a "control unit glitch which needed a global recycle". 

Kobayashi received an error message on the dashboard, pulled over onto the side of the track and went through the prescribed procedures to reset the car's systems before continuing without problems. 

The problem on #8 was not fully understood by Toyota in the immediate aftermath of the Monza race. 

Vasselon called it "essentially a fuel system issue which is not exactly clear", adding: "We don't know what is causing it — it was not an electrical issue."

The car was initially brought into its garage for approximately four minutes while Toyota tried to understand the issue and the full fuel system was subsequently changed with the loss of just under 50 minutes.

Vasselon admitted that the right front corner had to be changed on #8 because the wheel had not been tightened properly when the car was in the garage for the first time. He called it a "side-effect" which damaged the hub. 

The new Toyotas ran without major issues through the opening two rounds of the 2021 at Spa and Portimao.

shares
comments

Related video

WRT has "regrets" about losing maiden WEC win at Monza

Previous article

WRT has "regrets" about losing maiden WEC win at Monza

Next article

Ferrari hopes to race hypercar in IMSA following WEC convergence

Ferrari hopes to race hypercar in IMSA following WEC convergence
Load comments
Why Toyota's Le Mans victory was not as simple as it looked Prime

Why Toyota's Le Mans victory was not as simple as it looked

Toyota scored its fourth Le Mans 24 Hours victory and a 1-2, with the #7 car of Kamui Kobayashi, Mike Conway and Jose Maria Lopez beating the #8. But although it looked straightforward from the outside, Toyota faced serious problem that had to be solved with some quick-thinking and ingenuity.

Le Mans
Aug 24, 2021
What we've learned from the Le Mans 24 Hours so far Prime

What we've learned from the Le Mans 24 Hours so far

The new dawn for the FIA World Endurance Championship has arrived at Le Mans, as Hypercars prepare to duel for victory in the world's oldest endurance race. Motorsport.com picks out the 10 things we have learned in the build up to the race.

Le Mans
Aug 21, 2021
Le Mans 2021: The team-by-team guide Prime

Le Mans 2021: The team-by-team guide

After a two-month delay due to the ongoing impact of the COVID-19 pandemic, the 2021 Le Mans 24 Hours is set to get underway with the start of the Hypercar era at the Circuit de la Sarthe.

Le Mans
Aug 21, 2021
Can Toyota's #7 crew break its Le Mans curse? Prime

Can Toyota's #7 crew break its Le Mans curse?

One Toyota, normally with the number 7 on the side, always seems to attract the bad luck in the Le Mans 24 Hours. Mike Conway, Kamui Kobayashi and Jose Maria Lopez are hoping for a change in fortune this time around, but face significantly more unknowns than in recent years

Le Mans
Aug 19, 2021
Why Glickenhaus should be taken seriously on its Le Mans bow Prime

Why Glickenhaus should be taken seriously on its Le Mans bow

Many were quick to dismiss Glickenhaus when the boutique American sportscar firm's entry into the top class of the Le Mans 24 Hours was announced. It's all-new LMH racer, powered by an engine built by a rally specialist, goes in as the underdog against Toyota but the mathematical odds suggest that it has more than just a faint hope of success.

Le Mans
Aug 18, 2021
How 1971's benchmark Le Mans team lost with the best car Prime

How 1971's benchmark Le Mans team lost with the best car

The JW Automotive Engineering team won twice at the Le Mans 24 Hours with ageing Fords and was considered the heavy favourite to add more victories to its tally after partnering with Porsche. But despite being armed with the all-conquering 917, this formidable combination was never as successful in real life as on the big screen.

Le Mans
Aug 15, 2021
Why Jose Maria Lopez isn’t motivated by emulating Fangio Prime

Why Jose Maria Lopez isn’t motivated by emulating Fangio

Having twice missed out on Formula 1 and reinvented himself as a touring car driver, Jose Maria Lopez has had a rocky ride to becoming a four-time world champion. One more would put him level with his nation's favourite son, but there's another prize he would value far more than the honour of matching Juan Manuel Fangio's tally.

WEC
Aug 14, 2021
The understated Le Mans legend who has earned a testimonial Prime

The understated Le Mans legend who has earned a testimonial

OPINION: After 24 Le Mans 24 Hours participations, 50-year-old Emmanuel Collard will be absent from the grid this year, stuck at the mercy of his gold driver grading. But, while he's not motivated by breaking start records, the French veteran is determined to return to the field next year.

WEC
Jul 24, 2021